Ford Sierra

1982-1993 of release

Repair and operation of the car



Ford Siyerra
+ 1.2. Identification of the car
+ 2. Maintenance
+ 3. General data
+ 4. Engines
+ 5. Coupling
+ 6. Transmissions
+ 7. Driveshaft and back bridge
- 8. Steering
   8.1. Technical characteristics
   8.2. Removal and installation of steering transfer
   8.3. Dismantling and assembly of steering transfer
   8.4. Removal and installation of a steering column
   8.5. Dismantling and assembly of a steering wheel
   - 8.6. Steering with the hydraulic booster
      8.6.1. Technical characteristics
      8.6.2. Removal and installation of steering transfer
      8.6.3. Removal and installation of the hydraulic pump
      8.6.4. Dismantling and assembly of steering transfer of CAM GEAR
      8.6.5. Dismantling and assembly of steering transfer of ZF
      8.6.6. Removal and installation of a steering column
      8.6.7. Dismantling and assembly of a steering wheel
      8.6.8. Removal of air from system of steering
+ 9. Suspension brackets
+ 10. Brake system
+ 11. Body
+ 12. Electric equipment


a773976c



8.6.8. Removal of air from system of steering

PERFORMANCE ORDER
1. To unscrew a stopper of filling of oil in system of steering with the hydraulic booster and to check oil level in system (at cold oil). In case of need to add oil to necessary level.

Prevention

Oil should be added slowly and it is impossible to shake capacity not to allow formation of vials of air in a tank.


2. To disconnect a negative wire (plug "1") from the ignition coil.
3. Several times to include a starter (every time approximately for 2 seconds), rotating at the same time steering wheel from an emphasis against the stop and adding oil (the help of other person is necessary) before stabilization of level of oil in a tank all the time and till the moment when oil ceases to leave vials of air.
4. To check oil level, in case of need to fill its quantity and to screw up a stopper.
5. To connect an electric wire to the ignition coil.
6. To execute a trial trip and after a stop of the car to check tightness of connections of system of steering with the hydraulic booster.
7. To finally check oil level in a tank at heated oil of system of steering with the hydraulic booster.